Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER Installation Manual download pdf

WARNING: If the information in this manual is not

followed exactly, a fire or explosion may result

causing property damage, personal injury, or

loss of life.

— Do not store or use gasoline or other

flammable vapors and liquids in the vicinity of

this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

• If you cannot reach your gas supplier, call

the fire department.

— Installation and service must be performed by

a qualified installer, service agency, or the gas

WARNING: Improper installation, adjust-

ment, alteration, service, or maintenance

can cause injury or property damage.

Refer to this manual for correct installa-

tion and operational procedures. For as-

sistance or additional information con-

sult a qualified installer, service agency,

or the gas supplier.

WARNING: This appliance is for installa-

tion only in a solid-fuel burning masonry

or UL127 factory-built fireplace, or in an

approved ventless firebox. It is design-

certified for these installations in accor-

dance with ANSI Z21.11.2. Exception: Do

not install this appliance in a factory-

built fireplace that includes instructions

stating it has not been tested or should

not be used with unvented gas logs.

WARNING: This is an unvented gas-fired heater. It uses air (oxygen) from the room in which it

is installed. Provisions for adequate combustion and ventilation air must be provided. Refer to

Air for Combustion and Ventilation

section on page 4 of this manual.

18", 24", and 30" Variable

Manually-Controlled Models

CGD3018P CCL3924P

CGD3924P CRL2718P

CGD3930P CRL3124P

CCL3018P

18", 24", and 30"

Thermostatically-Controlled

Models

CGD3924PT CGD3930PT

CGD3018PT CCL3018PT

CCL3924PT CCL3930PTA

Patent Pending

This appliance may be installed in an aftermarket,* permanently located, manufactured

(mobile) home, where not prohibited by local codes.

This appliance is only for use with type of gas indicated on the rating plate. This appliance

is not convertible for use with other gases.

* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer

(Smoky Mountain Oak Model Shown)

UNVENTED (VENT-FREE) PROPANE/LP

GAS LOG HEATER

OWNER’S OPERATION AND INSTALLATION

MANUAL

Save this manual for future reference.

For more information, visit www.desatech.com

BILTMORE SPLIT OAK, SEASONAL OAK

AND SMOKY MOUNTAIN OAK LOGS

Variable Manually-Controlled Models Also Design-Certified

As Vented Decorative Appliances

1 2 3 4 5 6 ... 43 44

Summary of Contents

Page 1 - GAS LOG HEATER

WARNING: If the information in this manual is notfollowed exactly, a fire or explosion may resultcausing property damage, personal injury, orloss of l

Page 2 - TABLE OF CONTENTS

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com10INSTALLING HEATER BASE ASSEMBLY WARNING: If instal

Page 3 - PRODUCT IDENTIFICATION

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com1111Figure 12 - Attaching Flexible Gas Hose to Heate

Page 4 - UNPACKING

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com12 CAUTION: Avoid damage to regulator. Hold gasregul

Page 5

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com1313INSTALLATIONContinuedONPOSITIONOFFPOSITIONFigure

Page 6

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com14INSTALLATIONContinuedFigure 20 - Installing Middle

Page 7

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com1515INSTALLATIONContinuedPinHole inGrate BaseBack Lo

Page 8

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com16Dual Burner Biltmore Split Oak Models WARNING: Fai

Page 9

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com1717INSTALLATIONContinued76Figure 34 - Installing Cr

Page 10 - INSTALLATION

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com18INSTALLATIONInstalling Logs (Cont.)Single Burner S

Page 11

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com1919OPERATING HEATERManually-Controlled ModelsFigure

Page 12

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com2SAFETY INFORMATION DANGER: Carbon monoxide poisonin

Page 13

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com201. Follow steps 1 through 5 under Lighting Instruc

Page 14

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com2121Figure 41 - Control Knob and Ignitor Button Loca

Page 15

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com22INSPECTING BURNERSCheck pilot flame pattern and bu

Page 16

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com2323LOGS• If you remove logs for cleaning, refer to

Page 17

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com24TROUBLESHOOTING WARNING: Turn off and un-plug heat

Page 18

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com2525OBSERVED PROBLEMBurner does light after ODS/pilo

Page 19 - OPERATING HEATER

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com26TROUBLESHOOTINGContinuedPOSSIBLE CAUSE1. Metal exp

Page 20

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com2727Adhesive-backedMountingClipFigure 50 - Locating

Page 21

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com28SERVICE HINTSWhen Gas Pressure Is Too Low• pilot w

Page 22 - INSPECTING BURNERS

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com2929SPECIFICATIONSDUAL BURNER SMOKY MOUNTAIN OAK AND

Page 23 - MAINTENANCE

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com33SAFETY INFORMATIONContinued1. This appliance is on

Page 24 - TROUBLESHOOTING

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com30ILLUSTRATED PARTSBREAKDOWNVariable Manually-Contro

Page 25

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com3131This list contains replaceable parts used in you

Page 26

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com32ILLUSTRATED PARTSBREAKDOWNThermostatically-Control

Page 27 - THERMOSTAT SENSING BULB

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com3333This list contains replaceable parts used in you

Page 28 - ACCESSORIES

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com34ILLUSTRATED PARTSBREAKDOWNThermostatically-Control

Page 29 - SPECIFICATIONS

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com3535This list contains replaceable parts used in you

Page 30 - BREAKDOWN

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com36ILLUSTRATED PARTSBREAKDOWNThermostatically-Control

Page 31 - PARTS LIST

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com3737This list contains replaceable parts used in you

Page 32

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com38ILLUSTRATED PARTSBREAKDOWNVariable Manually-Contro

Page 33

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com3939KEY PART NUMBERNO. CRL2718P CRL3124P DESCRIPTION

Page 34

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com4AIR FOR COMBUSTION ANDVENTILATIONToday’s homes are

Page 35

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com40These Parts Centrals are privately owned businesse

Page 36

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com41411. Where will the product be used? ❍ Li

Page 37

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com422701 Industrial DriveP.O. Box 90004Bowling Green,

Page 38

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com4343NOTES___________________________________________

Page 39

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com44KEEP THIS WARRANTYWARRANTY INFORMATIONAlways speci

Page 40 - PARTS CENTRAL

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com55Confined and Unconfined SpaceNational Fuel Gas Cod

Page 41 - 107124-01E

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com6AIR FOR COMBUSTION ANDVENTILATIONContinuedVENTILATI

Page 42 - Required

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com77INSTALLATION WARNING: A qualified service person m

Page 43

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com8INSTALLATIONContinuedNOTICE: Manual control heaters

Page 44 - WARRANTY INFORMATION

107124-01EFor more information, visit www.desatech.comFor more information, visit www.desatech.com99Figure 7 - Minimum Mantel Clearances Without Using

Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER Installation Manual

Browse online or download Installation Manual for Space heaters Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER. Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER Installation manual User Manual

Summary of Contents

More documents for Space heaters Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER

Comments to this Manuals

Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER Installation Manual

Browse online or download Installation Manual for Space heaters Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER. Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER Installation manual User Manual

Summary of Contents

More documents for Space heaters Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER

Comments to this Manuals

Related products and manuals for Space heaters Vanguard UNVENTED (VENT-FREE) PROPANE/LP GAS LOG HEATER